|
|
|
| MAGNETIC PARTICLE FLAW INSPECTION SYSTEM |
STANDARD MODEL・・Equiped super function
|
 |
| ● |
This model can perform every kinds of magnetic particle flaw inspection
in our unit.
|
|
circular magnetization、longitudial magnetization、
continuous magnetization, residual magnetization、
threading bar magnetization、
current induction magnetization, AC magnetization、
AC demagnetization、DC magnetization, DC demagnetization |
| ● |
Three phase full wave recitification by SCR DC-AC dual out put by SCR. |
| ● |
DC magnetizing→DC demagnetizing、AC magnetizing→AC demagnetizing are
performed. |
| ● |
「Spark preventive function by soft starter」 |
|
「Automatic current failure detect and display function」 |
|
「AC/DC select PB SW operation function] e.t.c. |
|
Latest functions are fully equipped. |
|
| ・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・ |
FAMILIARIZED MODEL・・Rigidly constructed, Less cost .and Simple operation
|
| ● |
Single phase full wave rectification by SCR. |
| ● |
DC-AC dual magnetization、DC-AC dual demagnetization |
| ● |
Familiarized model with renewal main board. |
| ● |
To make clamp the workpiece, either manual or air cylinder drive is available. |
| ● |
Finisher of magnetic particle liquid bath is selectable either steel plate
or stainless plate made. |
| ● |
Inspection gril is selectable either wooden or stainless made. |
| ● |
Dark room is structured by steel plate and high brightness type black light
is equipped. |
|
| ・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・ |
| PRACTICAL MODEL・・Suitable for sampling test and R&D. |
| ● |
There are separated type power source ( "S"series) and integrated
type power sources (S?series) |
| ● |
Separated type power sources contains prod magnetize terminal and it can
use everywhere because of portable. |
| ● |
Darkroom is prefabiricated by pipe, easy to carry in and install in small room. |
| ● |
Magnetizing power supply unit is equiped with latest function NQ-400S、300S、200S、 |
| ● |
Magnetic particle liquid bath is always stirred by 0.2ｋｗ self-suck type
pump. |
|
 |
| ・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・ |
| COMPOSITE MAGNETIZING MODEL・・Detect both longitudunal and transversal flaw |
| ● |
Duovec type magnetization by DC magnetic field enabled to detect both longitudinal flaw and also transverseflaw in one magnetization. |
| ● |
Duovec type magnetization by AC magnetic field, NR-40A, 30A and 20A series
are mounted Demagnetizer system in it. |
| ● |
Duty cycle time is 8 sec. per piece from cycle start to finish by automatic
mode. |
| ● |
Special part holder is duly prepared. |
| ● |
high brightness type Black light is equipped to make curtainless. |
|
| ・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・ |
| WET HOLIZONTAL MODEL・・For detection of steel parts |
 |
| ● |
Simple installation! Only carry in working space and connect three-phase
AC power source 200V. |
| ● |
Well-lighted working enviroment. By adopting high intensity spread type
black light, inspectable at the large space without curtain. |
| ● |
Simple operation! While magnetizing, spray magnetic particle liquid only
then, all flaws are detected cleary. |
| ● |
Transversal flaw by coil magnetizing or vertical flaw by head magnetizing are detectable respectively. |
| ● |
AC attenuation type demegnetizing function is mounted and it can be demagnetized
within 6sec/pc. |
|
社沿 会社沿革革 革革
|
|
